Kemerovo, Russian Federation
Kemerovo, Russian Federation
Kemerovo, Russian Federation
Kemerovo, Russian Federation
Kemerovo, Russian Federation
Kemerovo, Russian Federation
Kemerovo, Russian Federation
Modern highly sensitive and selective sensors are able to determine biologically active substances, which makes this direction one of the most popular areas of analytical chemistry. The study featured the electrochemical properties of new fiber materials based on single-wall carbon nanotubes with prospects of using them in the voltammetry of ascorbic acid. The authors developed a new technology to synthesize films from disordered single-wall carbon nanotubes by chemical vapor deposition. Fibers were produced from a solvent by wet-pulling of single-wall carbon nanotubes networks. Thin films of randomly oriented single-wall carbon nanotube bundles were deposited downstream of a floating aerosol CVD reactor, which included a high temperature furnace with a quartz tube. The synthesis of the single-wall carbon nanotube samples was performed at 825°C. Ethanol served as carbon source while ferrocene was used as catalyst precursor. The single-wall carbon nanotubes were collected on a nitrocellulose filter in the form of films with transmittances of 10% in the middle of the visible wavelength (550 nm). The method was optimized to involve air annealing at 300–320°C and a treatment with strong inorganic acids, i.e., HCl, HNO3 + H2SO4. The voltammetric curves recording included background electrolyte, scan rate, and preconditioning. These parameters were selected experimentally to obtain the maximal sensor response to ascorbic acid content. The anodic peak of ascorbic acid in the phosphate buffer electrolyte (pH 6.86) was observed at a potential of +0.2 V. The current and peak area of ascorbic acid oxidation depended neither on the time nor on the conditioning potential of the sensor. The linear dependences of these parameters on the concentration of ascorbic acid stayed within 50–500 μmol/L (8.8–90 mg/L) at a scan rate of 0.1 mV/s. The single-wall carbon nanotube microsensor had a length of 0.5 cm and an average width of 400 μm. Its sensitivity was two times as high as that of a disk glassy carbon electrode with a diameter of 5 mm. The experimental sensors proved effective in determining ascorbic acid in food products, pharmaceuticals, and biological fluids.
Carbon nanotubes, sensors, voltammetry, ascorbic acid
1. Baig N, Sajid M, Saleh TA. Recent trends in nanomaterial-modified electrodes for electroanalytical applications. Trends in Analytical Chemistry. 2019;111:47-61. https://doi.org/10.1016/j.trac.2018.11.044
2. Gupta P, Rahm CE, Griesmer B, Alvarez NT. Carbon nanotube microelectrode set: Detection of biomolecules to heavy metals. Analytical Chemistry. 2021;93(20):7439-7448. https://doi.org/10.1021/acs.analchem.1c00360
3. Tu Y, Lin Y, Ren ZF. Nanoelectrode arrays based on low site density aligned carbon nanotubes. Nano Letters. 2003;3(1):107-109. https://doi.org/10.1021/nl025879q
4. Duzmen S, Baytak AK, Aslanoglu M. A novel voltammetric platform composed of poly(aminopyrazine), ZrO2 and CNTs for a rapid, sensitive and selective determination of ascorbic acid in pharmaceuticals and food samples. Materials Chemistry and Physics. 2020;252. https://doi.org/10.1016/j.matchemphys.2020.123170
5. Pan PAN,Shou-GuoWU. Direct determination of ascorbic acid in fruits and vegetables by positive scan polarization reverse catalytic voltammetry. Chinese Journal of Analytical Chemistry. 2019;47(8):e19088-e19094. https://doi.org/10.1016/S1872-2040(19)61175-8
6. MuqaddasS, Aslam H, Hassan SU, Ashraf AR, AsgharMA, Ahmad M, et al.Electrochemical sensing of glucose and ascorbic acid via POM-based CNTs fiber electrode. Materials Science and Engineering: B. 2023;293. https://doi.org/10.1016/j.mseb.2023.116446
7. Nugent JM, SanthanamKSV, Rubio A, Ajayan PM. Fast electron transfer kinetics on multiwalled carbon nanotube microbundle electrodes. Nano Letters. 2001;1(2):87-91. https://doi.org/10.1021/nl005521z
8. Gong K,Chakrabarti S, Dai L. Electrochemistry at carbon nanotube electrodes: Is the nanotube tip more active than the sidewall? Angewandte Chemie International Edition. 2008;47(29):5446-5450. https://doi.org/10.1002/anie.200801744
9. Harreither W, Trouillon R, Poulin P, Neri W, Ewing AG, Safina G.Carbon nanotube fiber microelectrodes show a higher resistance to dopamine fouling. Analytical Chemistry. 2013;85(15):7447-7453. https://doi.org/10.1021/ac401399s
10. Yang C, Trikantzopoulos E, Jacobs CB, Venton BJ. Evaluation of carbon nanotube fiber microelectrodes for neurotransmitter detection: Correlation of electrochemical performance and surface properties. Analytica Chimica Acta. 2017;965;1-8. https://doi.org/10.1016/j.aca.2017.01.039
11. Shandakov SD,Kosobutsky AV, Vershinina AI, Sevostyanov OG, Chirkova IM, Russakov DM, et al. Electromechanical properties of fibers produced from randomly oriented SWCNT films by wet pulling technique. Materials Science and Engineering: B. 2021;269. https://doi.org/10.1016/j.mseb.2021.115178
12. Zhilyaeva MA,Shulga EV, Shandakov SD, Sergeichev IV, Gilshteyn EP, Anisimov AS, et al. A novel straightforward wet pulling technique to fabricate carbon nanotube fibers. Carbon. 2019;150:69-75. https://doi.org/10.1016/j.carbon.2019.04.111
13. Moisala A, Nasibulin AG, Shandakov SD, Jiang H, Kauppinen EI. On-line detection of single-walled carbon nanotube formation during aerosol synthesis methods. Carbon. 2005;43(10):2066-2074. https://doi.org/10.1016/j.carbon.2005.03.012
14. Zhang W, Chen J, Li Y, Yang W, Zhang Y, Zhang Y. Novel UIO-66-NO2@XC-72 nanohybrid as an electrode material for simultaneous detection of ascorbic acid, dopamine and uric acid. RSC Advances. 2017;7(10):5628-5635. https://doi.org/10.1039/C6RA26933H
15. Ma C, Xu P, Chen H, Cui J, Guo M, Zhao J. An electrochemical sensor based on reduced graphene oxide/β-cyclodextrin/multiwall carbon nanotubes/polyoxometalatetetracomponent hybrid: Simultaneous determination of ascorbic acid, dopamine and uric acid. Microchemical Journal. 2022;180. https://doi.org/10.1016/j.microc.2022.107533
16. Filik H, Avan AA, Aydar S. Simultaneous detection of ascorbic acid, dopamine, uric acid and tryptophan with Azure A-interlinked multi-walled carbon nanotube/gold nanoparticles composite modified electrode. Arabian Journal of Chemistry. 2016;9(3):471-480. https://doi.org/10.1016/j.arabjc.2015.01.014
17. Peng X, Xie Y, Du Y, Song Y, Chen S. Simultaneous detection of ascorbic acid, dopamine and uric acid based on vertical N-doped carbon nanosheets/three-dimensional porous carbon. Journal of Electroanalytical Chemistry. 2022;904. https://doi.org/10.1016/j.jelechem.2021.115850
18. Hsine Z, Bizid S, Mlika R, Sauriat-Dorizon H, Haj Said A, Korri-Youssoufi H. Nanocomposite based on poly (para-phenylene)/chemical reduced graphene oxide as a platform for simultaneous detection of ascorbic acid, dopamine and uric acid. Sensors. 2020;20(5). https://doi.org/10.3390/s20051256
19. Li H, Wang Y, Ye D, Luo J, Su B, Zhang S, et al. An electrochemical sensor for simultaneous determination of ascorbic acid, dopamine, uric acid and tryptophan based on MWNTs bridged mesocellular graphene foam nanocomposite. Talanta. 2014;127:255-261. https://doi.org/10.1016/j.talanta.2014.03.034
20. Aryal KP, Jeong HK. Carbon nanofiber modified with reduced graphite oxide for detection of ascorbic acid, dopamine, and uric acid. Chemical Physics Letters. 2020;739. https://doi.org/10.1016/j.cplett.2019.136969
21. Wang Y, Yang T, Hasebe Y, Zhang Z, Tao D. Carbon black-carbon nanotube co-doped polyimide sensors for simultaneous determination of ascorbic acid, uric acid, and dopamine. Materials. 2018;11(9). https://doi.org/10.3390/ma11091691
22. Fernandes DM, Costa M, Pereira C, Bachiller-Baeza B, Rodríguez-Ramos I, Guerrero-Ruiz A, et al. Novel electrochemical sensor based on N-doped carbon nanotubes and Fe3O4 nanoparticles: Simultaneous voltammetric determination of ascorbic acid, dopamine and uric acid. Journal of Colloid and Interface Science. 2014;432:207-213. https://doi.org/10.1016/j.jcis.2014.06.050
23. Iranmanesh T, Foroughi MM, Jahani S, Zandi MS, Nadiki HH. Green and facile microwave solvent-free synthesis of CeO2 nanoparticle-decorated CNTs as a quadruplet electrochemical platform for ultrasensitive and simultaneous detection of ascorbic acid, dopamine, uric acid and acetaminophen. Talanta. 2020;207. https://doi.org/10.1016/j.talanta.2019.120318
24. Singh A, Sharma A, Arya S.Electrochemical sensing of ascorbic acid (AA) from human sweat using Ni-SnO2 modified wearable electrode. Inorganic Chemistry Communications. 2023;152. https://doi.org/10.1016/j.inoche.2023.110718
25. Compton RG, Banks CE. Understanding voltammetry. World Scientific, 2007. 371 p.
